Sterndrives.Com	Mercruiser Sterndrive Information
	Mercruiser Parts Mercruiser Help Mercruiser Manuals Mercruiser Tools Mercruiser Sterndrives Contact

Mercruiser Standard Ignition Tune-Up Kits

[Standard Points-Style Ignition][Thunderbolt Ignition][Delco EST & HEI Electronic Ignition][Ignition & EFI Tools]

Click HERE for the Tune-Up Kit Chart.

Keeping your engine well tuned will improve performance and save fuel. Performing a complete tune-up can often take care of nagging running and starting problems. It is more difficult to troubleshoot a poor running engine that is not tuned.

Thousands of "do-it-yourselfer" customers perform their own tune-ups every year and they save good money doing it.
With a factory Service Manual and the correct tools, tune-up's are snap.

The Engine Owners Manual that came with your engine has a wealth information pertaining to
tune-up and maintenance procedures and schedules.

Conventional (points-style) Tune-Up Kits
34235T1 Tune-Up Kit $18.00 Fits GM in-line 4 & 6 cyl engines with conventional Delco ignition
392-6324T1 Tune-Up Kit $25.00 Fits Mercruiser 3.0L, 3.7L, 3.8L(V6), 5.7L Ski and Ford 233(V8) with Prestolite Ignition
801766 Tune-Up Kit $36.00 Fits GM engines with conventional Delco ignition
801768 Tune-Up Kit $42.00 Fits Ford V8 engines with Autoliye ignition. NO LONGER SOLD
391-5090T1 Tune-Up Kit $37.00 Fits Ford and GM V8 engines with Mallory ignition
801767 Tune Up Kit $45.00 Fits Ford and GM engines with Mercury ignition. NO LONGER SOLD
392-6325T1 Tune-Up Kit $27.00 Fits Mercruiser Ford 888 (s/n 3108723 and above) and Ford 233 (s/n 4173000 and above) with Prestolite ignitions with clip-down cap

A complete tune-up would address the following items:

Distributor Cap and Rotor Breaker Points and Condenser (conventional ignition) Spark Plug Wires Spark Plugs Fuel Filters (often more than one) Carburetor (adjustment or rebuild) Fuel Injection Components (EFI and MPI systems) Belts (serpentine or v-belt) Flame Arrestor (clean & inspect) Hoses (water and oil lines) and Hose Clamps Oil and Oil Filter Batteries and Battery Cable Connections

Dwell and/or Timing Idle Mixture and Choke Adjustements Shift Cable Adjustment Engine Alignment and Mount Inspection Drive Lube, Power Steering Fluid $ Trim Fluid levels Complete Engine Inspection Complete Steering and Gimbal Inspection Grease Propshaft, gimbal and steering Inspect Drive or Transmission Check and/or Replace Anodes Exhaust Tubes and Clamps Ground and Bonding Cable Connections

Use original Mercruiser factory parts for your tune-up or service.
Send your information to: sterndrives@bellsouth.net



   If you prefer, you can simply EMAIL us with your question(s) or request.

Mercruiser Sterndrive Parts. Pre-Alpha, R, MR and MC1 Parts Alpha One Parts Seal Kits Alpha One Gimbal (Transom) Parts and Kits Alpha Gen II Parts Alpha Gen II Gimbal (Transom) Parts and Kits Bravo One Parts Bravo Two Parts Bravo Three Parts Bravo Gimbal (Transom) Parts and Kits TR and TRS Parts Transom Seal Kits Gimbal Bearings Shift Cable Kits Gear Kits Shift Interuptor Switch Kits Anodes and Zinc Kits Water Pump Kits Power Trim Pump Kits and Trim System Parts Decal Sets Sterndrive Special Tools Mercruiser shop Manuals Propellers Remote Controls Gauges Trim Sender Switches Trim Cylinder Assemblies

Mercruiser Engine Parts Filters and Filter Kits Tuneup Kits Carburetor Rebuild Kits Carburetors Raw Water Pump Kits Circulation Water Pumps Spark Plugs Spark Plug Wire Kits Gasket Sets Exhaust Manifolds Exhaust Elbows Exhaust Riser Kits Exhaust Water Shutter Kits Ignition Modules and Ignition Coils Cooling System Parts Starter Motors Solenoids Alternators and Charging Systems Belts and Belt-Pulley Kits Drive Couplers Fuel Pumps (Mechanical and Electric) Wire Harnesses Gauges and Instruments Partial Engine Assemblies Grease, Lubricants and Adhesives

©2004 Sterndrives.Com •Email • About Us • Home • Return Policy

• Mercruiser Help • Shop Manuals • Search • Contact